Content Source: 2021 GENERAL XP 4 1000 Owner’s Manual (9939900 R01) > Safety Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Safety Labels and Locations

Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle.
If any label becomes illegible or comes off, contact your POLARIS dealer to purchase a replacement. Replacement safety labels are provided by POLARIS at no charge. The part number is printed on the label.

Proper Use Warning (7185827)

The Proper Use Warning is located on the center console.
Require Proper Use of Your Vehicle
Do your part to prevent injuries:

  • Do not allow careless or reckless driving.
  • Make sure operators are 16 or older with a valid driver’s license.
  • Do not let people drive or ride after using alcohol or drugs.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
  • Do not exceed seating capacity: 4 occupants
Driving on public roads may be hazardous and could be a violation of law.

Image

Intake Duct Caution (7182087)

CAUTION
Air intake tube must be fully seated on air box and throttle body. Inspect full perimeter if serviced. Clamps at air box and throttle body must be torqued to 49 in-lbs (5.5 N-m) or severe engine damage may occur.

Payload Warning / Shift Caution (7185784)

The Payload/Shift Caution safety label is located on the center console.
WARNING
POLARIS Never Exceed If Total Payload Exceeds
GENERAL 43 MPH (69 kph) 430 lbs. (195 kg)
GENERAL 4 50 MPH (80 kph) 645 lbs. (292 kg)
CAUTION
To avoid transmission damage, shift only when vehicle is stationary and at idle. When vehicle is stopped, place shift in parked position.

Fuel Transport Warning (7186122)

The Fuel Transport Warning is located in the cargo box.
WARNING
NEVER carry fuel or other flammable liquids on this vehicle. Failure to follow this instruction could lead to serious burn injuries or death.

Clutch Cover Warning (7177469)

  • The clutch cover warning is located on the clutch cover.
  • WARNING
  • Improper service or maintenance of this PVT system can result in vehicle damage, SEVERE INJURY or DEATH.
  • Always look for and remove debris inside and around clutch and vent system when replacing belt.
  • Read owner’s manual or see authorized POLARIS dealer.

Image

Load / Passenger / Tire Pressure Warning (7300170)

  • The Load/Passenger/Tire Pressure warning decal is located on the front panel of the rear cargo box .
  • WARNING
  • Passengers can be thrown off. This can cause serious injury or death.
  • Never carry passengers in cargo box.

Image
IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTING IN SERIOUS INJURY OR DEATH.
  • Reduce speed and allow greater distance for braking when carrying cargo.
  • Overloading or carrying tall, off-center, or unsecured loads will increase your risk of losing control. Loads should be centered and carried as low as possible in box.
  • For stability on rough or hilly terrain, reduce speed and cargo.
  • Be careful if load extends over the side of the box.

RANGER

GENERAL BASE

GENERAL

GENERAL 4

GENERAL XP

GENERAL XP4

MAXIMUM CARGO BOX LOAD

600 lbs.


(272 Kg)

600 lbs.


(272 Kg)

600 lbs.


(272 Kg)

600 lbs.


(272 Kg)

600 lbs.


(272 Kg)

TIRE PRESSURE IN PSI (KPa)

FRONT 10 (69)


REAR 18 (125)

FRONT 12 (87)


REAR 14 (96)

FRONT 18 (124)


REAR 20 (137)

FRONT 10 (69)


REAR 14 (97)

FRONT 16 (110)


REAR 22 (152)

MAXIMUM WEIGHT CAPACITY


INCLUDES WEIGHT OF OPERATOR, PASSENGERS, CARGO, AND ACCESSORIES

1030 lbs.


(467 Kg)

1030 lbs.


(467 Kg)

1280 lbs.


(580 Kg)

1000 lbs.


(454 kg)

1200 lbs.


(544 kg)

Read Operation and Maintenance Manual for more detailed loading information.

    

Air Box Caution

CAUTION
Use a Polaris approved air filter. The use of a non-Polaris approved air filter may cause engine damage. Before installing filter, ensure there is no dirt or debris in the clean side of the intake tube. The air filter must be properly seated before the lid is reinstalled. Please reference your owner’s manual for additional information regarding air filter service.

Seat Belt/Drive Responsibly Warning (7185097)

WARNING
Improper vehicle use can result in SEVERE INJURY or DEATH
BE PREPARED
  • Fasten seat belts.
  • Wear an approved helmet and protective gear.
  • ALWAYS use cab nets and/or doors.
  • Each rider must be able to sit with back against seat, feet flat on the floor, and hands on steering wheel or hand holds. Stay completely inside the vehicle.
Drive Responsibly
Avoid loss of control and rollovers:
  • Avoid abrupt maneuvers, sideways sliding, skidding or fishtailing, and never do donuts.
  • Slow down before entering a turn.
  • Avoid hard acceleration when turning, even from a stop.
  • Plan for hills, rough terrain, ruts and other changes in traction and terrain. Avoid paved surfaces.
  • Avoid sidehilling (riding across slopes).
Be Sure Riders Pay Attention and Plan Ahead
If you think or feel the vehicle may tip or roll, reduce your risk of injury:
  • Keep a firm grip on the steering wheel or hand holds and brace yourself.
  • Do not put any part of your body outside of the vehicle for any reason.
Rollovers have caused severe injuries and death, even on flat, open areas.

© Copyright Polaris Inc. All rights reserved.