Content Source: 2021 Indian Challenger Owner’s Manual (9931587 R01) > Maintenance Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Troubleshooting

For your personal safety, do not attempt inspection or repairs not fully described in this rider’s manual. Contact an authorized dealer for service if you cannot determine the cause of a problem or if the inspection/repair exceeds your mechanical ability or tool resources. Do not perform any inspection or repair with the engine running.

Engine Cranks But Will Not Start

Possible Cause Possible Remedy/Action
Low Fuel Verify fuel level.
Fuel Pump Inoperative Turn engine STOP switch to RUN. Turn the power switch on. The fuel pump should run momentarily and then stop. Check the fuel pump/ignition circuit breaker.
Battery Voltage Too Low Fully charge the battery.
Spark Plug(s) Fouled Inspect spark plugs.
Spark Plug Wire(s) Disconnected or Loose Be sure spark plug wires are securely fastened.
Low Compression Please see your dealer for an engine compression test.

Starter Motor Clicks, Does Not Turn or Turns Slowly

Possible Cause Possible Remedy/Action
Engine Stop/Run Switch in Stop Position Place switch in RUN position.
Battery Discharged Fully charge the battery.
Battery Cables Loose or Corroded Inspect battery cables.
Transmission In Gear Shift transmission into neutral or pull the clutch lever in to disengage the clutch.
Key Fob Not Authenticated Make sure key fob is within range and that key fob battery voltage is not low.
Sidestand is Down With Transmission in Gear Shift to neutral or retract the sidestand fully.

Engine Starts But Misses or Runs Poorly

NOTICE
Turn engine OFF before inspecting any of these items.
Possible Cause Possible Remedy/Action
Battery Discharged Fully charge the battery.
Battery Cables Loose or Corroded Inspect battery cables and connections.
Spark Plug(s) Fouled Inspect spark plugs.
Spark Plug Wire(s) Loose or Wet Inspect spark plug wires, ensure dry/secure.
Contaminated Fuel Inspect fuel for water/contamination. Please see your dealer.
Engine Oil Level Incorrect Or Wrong Type Inspect level and quality of oil.
Loose, Broken, Shorted Ignition Coil Wires Inspect coil primary wires. Please see your dealer.
Air Intake Restricted Inspect air filter.
Intake Leaks Inspect air box, throttle body and intake boot joints.

Shifting Difficulties or Hard to Find Neutral

Possible Cause Possible Remedy/Action
Shift Linkage Bushings Dry Or Worn Lubricate shift linkage.
Clutch Damage Replace clutch.
Clutch Cable Not Adjusted Properly Please see your dealer for inspection and adjustment.
Shift Linkage Not Adjusted Properly Please see your dealer for inspection and adjustment.

Battery Charging Rate Low or Battery Discharges

Possible Cause Possible Remedy/Action
Loose/Corroded Charging Circuit Connection Check/clean battery cable connections. Check/clean charging circuit connections. Please see your dealer.
Accessory Load Exceeds Charge Rate Limit accessory operation when the engine is off.
Improperly Wired Accessory (Current Draw) Please see your dealer to check charging system output and current draw.

Brake Noise/Poor Brake Performance

NOTICE
See your dealer if brake performance does not return after these inspections.
Possible Cause Possible Remedy/Action
Dust/Dirt On Brake Disc(s) Clean disc.
Worn Pads Or Disc/Brake Disc Damage Inspect pads.
Brake Fluid Level Low Or Fluid Contaminated Inspect fluid level/fluid condition.

Anti-Lock Brake Light Remains Illuminated or Illuminates Intermittently

Possible Cause Possible Remedy/Action
Blown fuse Check the fuses. See Fuse Replacement.
Debris lodged in components Inspect wheel speed sensor for debris.
Damage caused by debris Inspect wheel speed sensor for cracked housing.
Damaged components See service manual or authorized dealer.

© Copyright Polaris Inc. All rights reserved.