Content Source: 2021 RZR XP / XP4 1000 High Lifter Owner’s Manual (9931526 R03) > Safety Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Safety Labels and Locations

Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle
If an informational or graphic label becomes illegible or comes off, contact your POLARIS dealer to purchase a replacement. Replacement safety labels are provided by POLARIS at no charge. The part number is printed on the label.
Warning Labels
Payload Warning

Image

Image

Proper Use Warning

WARNING
Require Proper Use of Your Vehicle
Do your part to prevent injuries:
  • Do not allow careless or reckless driving.
  • Make sure operators are 16 or older with a valid driver’s license.
  • Do not let people drive or ride after using alcohol or drugs.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
  • RZR: Do not exceed seating capacity: 1 passenger.
  • RZR 4: Do not exceed seating capacity: 3 passengers.

Payload Warning

WARNING:

RZR

Never Exceed

If Total Payload Exceeds

XP 1000 High Lifter

68 MPH (109 km/h)

430 lbs. (195 kg)

XP4 1000 High Lifter

62 MPH (109 km/h)

860 lbs. (390 kg)

Riders Warning

Be Sure Riders Pay Attention and Plan Ahead
If you think or feel the vehicle may tip or roll, reduce your risk of injury:
  • Keep a firm grip on the steering wheel or hand holds and brace yourself.
  • Do not put any part of your body outside of the vehicle for any reason.

Drive Responsibly Warning

WARNING:
Drive Responsibly
Rollovers have caused severe injuries and death, even on flat, open areas.
Avoid loss of control and rollovers:

  • Avoid abrupt maneuvers, sideways sliding, skidding or fishtailing, and never do donuts.
  • Slow down before entering a turn.
  • Avoid hard acceleration when turning, even from a stop.
  • Plan for hills, rough terrain, ruts and other changes in traction and terrain.
  • Avoid paved surfaces.
  • Avoid sidehilling (riding across slopes).

Image

Air Box Caution

CAUTION:
Air Box Caution

Use a Polaris approved air filter. The use of a non-Polaris approved air filter may cause engine damage. Before installing filter, ensure there is no dirt or debris in the clean side of the intake tube. The air filter must be properly seated before the lid is reinstalled. Please reference your owner’s manual for additional information regarding air filter service.

Image

Seat Belt Warning

Improper vehicle use can result in SEVERE INJURY or DEATH.
Be Prepared

  • Fasten seat belts.
  • Wear an approved helmet and protective gear.
  • ALWAYS use cab nets and/or doors.
  • Each rider must be able to sit with back against seat, feet flat on the floor, and hands on steering wheel or hand holds. Stay completely inside the vehicle.

Image


LOCATE AND READ OWNER’S MANUAL. FOLLOW ALL INSTRUCTIONS AND WARNINGS. ALWAYS REVIEW SAFETY VIDEO AND TAKE ROHVA® TRAINING (rohva.org).

Fuel Transport Warning

NEVER carry fuel or other flammable liquids on this vehicle.
Failure to follow this instruction could lead to serious burn injuries or death.

Image

Belt Debris Warning

Improper service or maintenance of this PVT system can result in vehicle damage, SEVERE INJURY or DEATH.
Always look for and remove debris inside and around the clutch and vent system when replacing the belt.
Read owner’s manual or see authorized POLARIS dealer.

Belt Debris Warning

Image

Load / Passenger / Tire Pressure Warning

The Load / Passenger / Tire Pressure Warning is located at the rear of the vehicle in the cargo box.

Image
WARNING
  • Never carry passengers in cargo box.
  • Passengers can be thrown off. This can cause serious injury or death.
WARNING
IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTING IN SERIOUS INJURY OR DEATH.
  • Reduce speed and allow greater distance for braking when carrying cargo.
  • Overloading or carrying tall, off-center, or unsecured loads will increase your risk of losing control. Loads should be centered and carried as low as possible in box.
  • For stability on rough or hilly terrain, reduce speed and cargo.
  • Be careful if load extends over the side of the box.
  RZR XP 1000 High Lifter RZR XP 4 1000 High Lifter
MAXIMUM CARGO BOX LOAD 300 lbs. (136 kg) 300 lbs. (136 kg)
TIRE PRESSURE IN PSI (KPa) FRONT 18 (124)
REAR 18 (124) 		FRONT 18 (124)
REAR 18 (124)
MAXIMUM WEIGHT CAPACITY
INCLUDES WEIGHT OF OPERATOR, PASSENGERS, CARGO AND ACCESSORIES 		740 lbs. (336 kg) 900 lbs. (408 kg)
Read Operation and Maintenance Manual for more detailed loading information.

© Copyright Polaris Inc. All rights reserved.