Periodic Maintenance Chart

Content Source: 2021 RZR 570 Owner’s Manual (9931521 R02) > Maintenance Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Periodic Maintenance Chart

Any qualified repair shop or person may maintain, replace or repair the emission control devices or systems on your vehicle. An authorized POLARIS dealer can perform any service that may be necessary for your vehicle. POLARIS also recommends POLARIS parts for emissions-related service, however equivalent parts can be used.

It is a potential violation of the Clean Air Act if a part supplied by an aftermarket parts manufacturer reduces the effectiveness of the vehicle’s emission controls. Tampering with emission controls is prohibited by federal law.

Owners are responsible for performing the scheduled maintenance identified in this owner’s manual.

Careful periodic maintenance will help keep your vehicle in the safest, most reliable condition. Inspection, adjustment and lubrication of important components are explained in the periodic maintenance chart.

Inspect, clean, lubricate, adjust and replace parts as necessary. When inspection reveals the need for replacement parts, genuine POLARIS parts are available from your POLARIS dealer. Equivalent parts may be used for emissions-related service.

Service and adjustments are important for proper vehicle operation. If you're not familiar with safe service and adjustment procedures, a qualified dealer can perform these operations.

Vehicles subjected to heavy or severe use patterns must be inspected and serviced more frequently.

Severe Use Definition

Frequent immersion in mud, water or sand
Frequent or prolonged operation in dusty environments
Racing or race-style high RPM use
Prolonged low speed, heavy load operation
Extended idle
Short trip cold weather operation

Pay special attention to the oil level. A rise in oil level during cold weather can indicate contaminants collecting in the oil sump or crankcase. Change oil immediately if the oil level begins to rise. Monitor the oil level, and if it continues to rise, discontinue use and determine the cause. Your POLARIS dealer can assist.

Maintenance Chart Key

Symbol	Description
XU	Perform these procedures more often for vehicles subjected to severe use.
D	Have an authorized POLARIS dealer or other qualified person perform these services.

WARNING

Improperly performing the procedures marked with a D could result in component failure and lead to serious injury or death. Have an authorized POLARIS dealer or other qualified person perform these services.

Maintenance Chart Table

Perform all services at whichever maintenance interval is reached first. Record maintenance and service in the Maintenance Log chapter.

Item		Maintenance Interval (whichever comes first)			Remarks
Item		Hours	CLNDR	Miles (Km)	Remarks
	Steering		Pre-Ride		Inspect and make adjustments as needed. See the Pre-Ride Inspection section for details.
	Front suspension
	Rear suspension
	Tires
	Brake fluid level
	Brake pedal travel
	Brake system
	Wheels/fasteners
	Frame fasteners
	Engine oil level
	Intake pre-filters
	Air Filter
	Coolant	-	Daily	-	Check level
XU	Power steering unit (if equipped)	-	Daily	-	Inspect daily; clean often
	Headlamp/tail lamp	-	Daily	-	Check operation; apply dielectric grease if replacing
XU	Air filter, main element	-	Weekly	-	Inspect; replace as needed
XU D	Brake pad wear	10 H	Monthly	100 (160)	Inspect periodically
XU	Engine breather	25 H	Monthly	150 (250)	Inspect; replace if necessary
	Fuel System	25 H	Monthly	150 (250)	Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
	Battery	25 H	Monthly	250 (400)	Check terminals; clean; test
XU	Engine oil change	25 H	Monthly	-	Break-in oil and filter change
	Air Filter	25 H	Monthly	-	Break-in air filter check. Inspect; replace as necessary
XU	Demand drive fluid	25 H	Monthly	-	Break-in oil level check
XU	Transmission oil (main gearcase)	25 H	Monthly	-	Break-in oil level check
	Throttle body air intake ducts/flange	50 H	6 M	300 (500)	Inspect duct for proper sealing/air leaks
XU	Shock Absorbers	50 H	-	500 (800)	Inspect for leaks, loose joints, and wear
XU	General lubrication	50 H	3 M	500 (800)	Lubricate all fittings, pivots, cables, etc.
XU	Oil lines, fasteners (if equipped)	50 H	6 M	500 (800)	Inspect for leaks and loose fittings
	Shift Linkage	50 H	6 M	500 (800)	Inspect, lubricate, adjust
D	Steering	50 H	6 M	500 (800)	Lubricate
XU	Front Suspension	50 H	6 M	500 (800)	Lubricate
XU	Rear Suspension	50 H	6 M	500 (800)	Lubricate
	Cooling system	50 H	6 M	500 (800)	Inspect coolant strength seasonally; pressure test system yearly
	Air Filter	100 H	6 M	1000 (1600)	Inspect; replace as necessary
XU	Engine oil change	100 H	6 M	1000 (1600)	Change the oil and filter
D	Fuel system	100 H	12 M	600 (1000)	Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump; replace lines every two years
XU	Spark plug	100 H	12 M	600 (1000)	Inspect; replace as needed
XU	Demand drive fluid	100 H	12 M	-	Change fluid
XU	Transmission oil (main gearcase)	100 H	12 M	-	Change fluid
XU	Radiator	100 H	12 M	1000 (1600)	Inspect; clean external surfaces
XU	Cooling Hoses	100 H	12 M	1000 (1600)	Inspect for leaks
XU	Engine mounts	100 H	12 M	1000 (1600)	Inspect
	Exhaust muffler/pipe	100 H	12 M	1000 (1600)	Inspect
XU	Wiring	100 H	12 M	1000 (1600)	Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc.
D	Clutches (drive and driven)	100 H	12 M	1000 (1600)	Inspect; clean; replace worn parts
	Drive belt	100 H	12 M	1000 (1600)	Inspect; replace as needed
D	Front wheel bearings	100 H	12 M	1000 (1600)	Inspect; replace as needed
D	Brake fluid	200 H	24 M	2000 (3200)	Change every two years
	Suspension bushings	250 H	24 M	2000 (3200)	Inspect; replace if necessary
	Spark arrester	200 H	24 M	2000 (3200)	Clean daily when driving in mud and water; replace a cracked or damaged arrester before operating (see the Spark Arrester section in this chapter)
XU	Shock Absorbers	250 H	-	2500 (4000)	Replace or rebuild (if applicable)
XU	Coolant	-	60 M	-	Replace coolant
XU	Valve clearance	500 H	-	5000 (8000)	Inspect; adjust as needed
D	Toe adjustment	-			Inspect periodically; adjust when parts are replaced
	Headlight aim	-			Adjust as needed

XU – Perform these procedures more often for vehicles subjected to severe use.

D – Have an authorized POLARIS dealer or other qualified person perform these services.