Content Source: 2020 RGR 500 / 570 / EPS Owner’s Manual (9931336 R02) > Safety Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Safety Labels and Locations

Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle.
If an informational or graphic label becomes illegible or comes off, contact your POLARIS dealer to obtain a replacement. Replacement safety labels are provided by POLARIS at no charge.
Image

  • Seat Belt / Driver Warning
  • Shift Caution

  • Proper Use Warning
  • Max Payload Warning

Maximum Payload Warning

WARNING
RANGER Never Exceed If Total Payload Exceeds
MID-SIZE 30 mph (49 kph) 750 lbs. (340 kg)
MID-SIZE CREW 35 mph (56 kph) 1000 lbs. (453 kg)

Shift Caution

CAUTION
To avoid transmission damage, shift only when vehicle is stationary and at idle. APPLY BRAKE TO START. When this vehicle is not in operation, or unattended, place shift in the park position.

Seat Belt / Drive Responsibly Warning

WARNING
Improper vehicle use can result in SEVERE INJURY or DEATH
Be Prepared
  • Fasten seat belts.
  • Wear an approved helmet and protective gear.
  • ALWAYS use vehicle cab doors if equipped.
  • Each rider must be able to sit with back against seat, feet flat on the floor, and hands on steering wheel or handholds. Stay completely inside the vehicle.
Drive Responsibly
  • Avoid loss of control and rollovers.
  • Avoid abrupt maneuvers, sideways sliding, skidding, or fishtailing, and never do donuts.
  • Slow down before entering a turn.
  • Avoid hard acceleration when turning, even from a stop.
  • Plan for hills, rough terrain, ruts, and other changes in traction and terrain. Avoid paved surfaces.
  • Avoid side hilling (riding across slopes).
Be Sure Riders Pay Attention and Plan Ahead
If you think or feel the vehicle may tip or roll, reduce your risk to injury:
  • Keep a firm grip on the steering wheel or handholds and brace yourself.
  • Do not put any part of your body outside of the vehicle for any reason.
Rollovers have caused severe injuries and death, even on flat, open areas.

Proper Use Warning

WARNING
Require Proper Use of Your Vehicle
Do your part to prevent injuries:
  • Do not allow careless or reckless driving.
  • Make sure operators are 16 or older with a valid driver’s license.
  • Do not let people drive or ride after using alcohol or drugs.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
  • Do not exceed seating capacity: 2 occupants.
Driving on public roads may be hazardous and could be a violation of the law.

Proper Use Warning (CREW)

WARNING
Require Proper Use of Your Vehicle
Do your part to prevent injuries:
  • Do not allow careless or reckless driving.
  • Make sure operators are 16 or older with a valid driver’s license.
  • Do not let people drive or ride after using alcohol or drugs.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
  • Do not exceed seating capacity: 4 occupants.

Fuel Transport Warning

The Fuel Transport Warning is located in the cargo box.

WARNING
NEVER carry fuel or other flammable liquids on this vehicle. Failure to follow this instruction could lead to serious burn injuries or death.

Image

Passenger/Tire Pressure Warning

The Passenger/Tire Pressure Warning is located in the cargo box.
WARNING
  • Passengers can be thrown off. This can cause serious injury or death.
  • Never carry passengers in cargo box.
WARNING
IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTING IN SERIOUS INJURY OR DEATH.
  • Reduce speed and allow greater distance for braking when carrying cargo.
  • Overloading or carrying tall, off-center, or unsecured loads will increase your risk of losing control. Loads should be centered and carried as low as possible in box.
  • For stability on rough or hilly terrain, reduce speed and cargo.
  • Be careful if load extends over the side of the box.
RANGER MID-SIZE MID-SIZE MID-SIZE CREW LI-ION EV / EV
MAXIMUM CARGO BOX LOAD 500 lbs. (226 kg) 500 lbs. (226 kg) 500 lbs. (226 kg)
TIRE PRESSURE IN PSI (KPa) FRONT 10 (69)
REAR 10 (69)
FRONT 10 (69)
REAR 14 (96)
FRONT 20 (138)
REAR 20 (138)
MAXIMUM WEIGHT CAPACITY INCLUDES WEIGHT OF OPERATOR, PASSENGER, CARGO AND ACCESSORIES 1000 lbs. (454 kg) 1250 lbs. (547 kg) 1000 lbs. (454 kg)
Read Operation & Maintenance Manual for more detailed loading information.

Clutch Cover Warning

WARNING

The Clutch Cover Warning is located on the clutch cover.

  • Improper service or maintenance of this PVT system can result in vehicle damage, SEVERE INJURY or DEATH.
  • Always look for and remove debris inside and around clutch and vent system when replacing belt.
  • Read owner’s manual or see authorized Polaris dealer.

Image

International Vehicle Safety Labels

General Alert (Non-Israel Models) (7183794)

  • Read the owner’s manual.
  • Never allow anyone under 16 years of age to operate this vehicle.
  • Never use alcohol or drugs before or while driving or riding.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access).
  • Wear approved helmet, goggles, and protective clothing.
  • Always wear seat belts.
  • Always use the cab nets or doors.
  • Never exceed seating capacity.
  • Always follow proper operating procedures.

Image

General Alert (Israel Models Only) (7184006)

  • Read the owner’s manual.
  • Never allow anyone under 16 years of age to operate this vehicle.
  • Never use alcohol or drugs before or while driving or riding.
  • This vehicle may be used on public roads.
  • Wear approved helmet, goggles, and protective clothing.
  • Always wear seat belts.
  • Always use the cab nets or doors.
  • Never exceed seating capacity.
  • Always follow proper operating procedures.

Image

Shift Alert (P/N 7183987)

  • To avoid transmission damage, shift only when vehicle is stationary and at idle.
  • APPLY BRAKE TO START. When this vehicle is not in operation, or unattended, place shift in the park position.

Image

Tire Pressure / Passenger Alert (7186344)

Never carry passengers in cargo box. Passengers can be thrown off. This can cause serious injury or death. Read owner’s manual. Never carry or transport fuel on this vehicle.
Image
Vehicle Maximum Cargo Box Load Maximum Capacity Tire Pressure in kpa/bar
RANGER EV 226 kg Occupants: 2 (Driver + 1 Passenger)
Weight: 454 kg
Front: 70 kPa/0,7 bar
Rear: 110 kPa/1,1 bar
RANGER MID-SIZE Front: 69 kPa/0,69 bar
Rear: 69 kPa/0,69 bar
RANGER MID-SIZE CREW Occupants: 4 (Driver + 3 Passengers)
Weight: 547 kg
Front: 69 kPa/0,69 bar
Rear: 96 kPa/0,96 bar

Clutch Cover Alert (P/N 7181427)

Keep body parts away from belt.
Label Location: on the clutch cover.

Image

Hitch Capacity Alert (P/N 7183975)

  • Read the owner’s manual.
  • TRAILER MAXIMUM WEIGHT: 1700 N ON LEVEL GROUND
  • HITCH MAXIMUM VERTICAL WEIGHT: 1100 N

Image

© Copyright Polaris Industries Inc. All rights reserved.