Content Source: 2022 Indian FTR Owner’s Manual (9931166 R02) > Maintenance Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Periodic Maintenance

Inspect, clean, lubricate, adjust and replace parts as necessary. When inspection reveals the need for replacement parts, use genuine INDIAN MOTORCYCLE parts available from your dealer. Record service and maintenance information in the Maintenance Log beginning on Maintenance Log.
Perform maintenance at the intervals specified in the Periodic Maintenance Interval Chart. Vehicles subjected to severe use must be inspected and serviced more frequently.

Severe Use Definition

  • high speed operation for extended periods
  • low speed operation for extended periods
  • operation in dusty or otherwise adverse conditions
  • operation in cold weather (temperatures below freezing)

Maintenance Intervals

The maintenance interval charts outline required maintenance and inspection based on vehicle miles. Each table states the number of miles that service is required on the vehicle. Some items or components may need to be serviced more often due to severe use. When the vehicle goes beyond 50,000 miles (80,000 km), return to the 500 miles (800 km) chart and start the interval process over.
XU - Perform these procedures more often for vehicles subjected to severe use.
D - Have an authorized INDIAN MOTORCYCLE dealer perform these services.
E - Emission Control System Service (California / International)

500 miles (800 km) Service

Item Remarks
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Engine Mount Fasteners Inspect; tighten, adjust
XU Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Inspect; lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Inspect
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

2,500 miles (4,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Cable Freeplay Inspect; adjust if necessary
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Inspect; adjust if necessary, lubricate with proper lubricant as directed
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Inspect; adjust if necessary, lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

5,000 miles (8,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Inspect; adjust if necessary
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Inspect; lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Replace at specified interval or every 2 years
D Front Forks and Front Axle Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Inspect; adjust if necessary, lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

10,000 miles (16,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
D Engine Compression Inspect; correct if necessary
XU Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
D / E Spark Plugs Inspect; replace as needed; torque to specification
  Battery Check terminals; clean; test
D Brake Fluid Replace (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Replace at specified interval or every 2 years
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

15,000 miles (24,000 km) Service

Item Remarks
XU Air Filter Replace
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Replace
D Chain Sliders Inspect; replace as needed
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Inspect; adjust if necessary
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Inspect; adjust if necessary
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Replace
D Front Forks and Front Axle Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Inspect; adjust if necessary, lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

20,000 miles (32,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
D Engine Compression Inspect; correct if necessary
XU Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
D / E Spark Plugs Inspect; replace as needed; torque to specification
D Valve Lash Clearance Inspect; adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Replace (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Inspect
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

25,000 miles (40,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Inspect; adjust if necessary
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Inspect; adjust if necessary
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Inspect
D Front Forks and Front Axle Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Inspect; adjust if necessary, lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

30,000 miles (48,000 km) Service

Item Remarks
XU Air Filter Replace
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Replace
D Chain Sliders Inspect; replace as needed
D Engine Compression Inspect; correct if necessary
XU Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
D / E Spark Plugs Replace
  Battery Check terminals; clean; test
D Brake Fluid Replace (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Lubricate with proper lubricant as directed
D Front Fork Oil Replace
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

35,000 miles (52,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Inspect; adjust if necessary
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Inspect; adjust if necessary
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Inspect
D Front Forks and Front Axle Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

40,000 miles (64,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
D Engine Compression Inspect; correct if necessary
XU Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
D / E Spark Plugs Inspect; replace as needed; torque to specification
D Valve Lash Clearance Inspect; adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Replace (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Inspect
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

45,000 miles (72,000 km) Service

Item Remarks
XU Air Filter Replace
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Replace
D Chain Sliders Inspect; replace as needed
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Inspect; lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Lubricate with proper lubricant as directed
D Front Fork Oil Replace
D Front Forks and Front Axle Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

50,000 miles (80,000 km) Service

Item Remarks
XU Air Filter Inspect; clean
D Crankcase Ventilation System Inspect; tighten, clean, adjust
D Drive Chain Inspect; clean, lubricate
D Chain Sliders Inspect; replace as needed
D Engine Compression Inspect; correct if necessary
D Engine Mount Fasteners Inspect; tighten, adjust
XU Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
E Evaporative Emission Control System Inspect; clean
E Exhaust System Inspect; tighten, adjust
D Fuel System Inspect; clean
D Oil Lines / Oil System Inspection Inspect; clean, adjust if necessary
D / E Spark Plugs Inspect; replace as needed; torque to specification
  Battery Check terminals; clean; test
D Brake Fluid Replace (DOT 4)
XU / D Brake Pads Inspect pad wear; replace if worn beyond service limit
D Clutch Lever Lubricate with proper lubricant as directed
D Clutch Cable Freeplay Inspect; adjust if necessary
D Control Cable Ends Lubricate with proper lubricant as directed
D Fasteners Inspect; tighten if necessary
D Front Brake Lever Adjust if necessary, lubricate with proper lubricant as directed
D Front Fork Oil Inspect
D Front Forks and Front Axle Inspect; adjust if necessary
D Head Light Inspect; adjust if necessary
D Gear Shift Pedal Inspect; lubricate, adjust if necessary
D Rear Brake Pedal Inspect; lubricate, adjust if necessary
D Driver and Passenger Pegs Inspect; lubricate if necessary
D Rear Shock Absorber Replace
D Rear Wheel Alignment Inspect; adjust if necessary
  Road Test Perform Road Test
D Sidestand Lubricate with proper lubricant as directed
D Steering Bearings Inspect
D Suspension Linkage, Rear Inspect
D Swing Arm and Rear Axle Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns
XU - Perform these procedures more often for vehicles subjected to severe use.
D - Have an authorized INDIAN MOTORCYCLE dealer perform these services.
E - Emission Control System Service (California)

© Copyright Polaris Inc. All rights reserved.