Content Source: Polaris Power® P5500 and P6500 Owner’s Manual (9931064 R02) > Operation Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Starting the Engine

DANGER
Never operate a generator indoors. Engine exhaust contains carbon monoxide, an odorless, colorless gas that can kill you within minutes. Always use this generator outdoors in a well-ventilated area.
WARNING
Before starting the engine, take the following precautions:
  • Ensure the generator is away from the fueling source.
  • The generator will vibrate during operation. Place the generator in a dry location and on a flat, level surface.
  • Unplug all power cords and extension cords from the generator.
  • Engage the wheel locks (if installed).
  • Perform an oil, fuel, and air filter check.

Electric Start

  1. Ensure the generator is away from the fueling source.
  2. Unplug all power cords and extension cords from the generator.
  3. Position the fuel switch to ON.
  4. For a cold engine start, position the choke lever to CLOSED. To restart a warm engine, leave the choke lever to OPEN.
  5. To start the generator using the ignition key, turn the ignition switch to the START position. When the engine starts, release the key. Do not operate the starter for more then 10 second intervals. If it doesn’t start turn the key to the OFF position for 5 seconds before repeating until it starts.
  • OFF
  • ON

Image

Recoil Start

  1. To start the generator using the recoil, lightly pull the starter recoil grip until resistance is felt. Then, firmly pull straight out.
    NOTICE
    Do not allow starter grip to snap back against the generator. Return it gently to prevent damage to the starter.

Image
  1. For a cold engine start, turn choke lever to CLOSED position.
  2. If the choke lever was positioned to CLOSED to start the engine, move it to OPEN as the engine warms up.

© Copyright Polaris Inc. All rights reserved.