Content Source: 2020 RANGER 1000 / RANGER CREW 1000 Owner’s Manual (9930790 R01) > Safety Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

RANGER 1000

Safety Labels and Locations

Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle.
If an informational or graphic label becomes illegible or comes off, contact your POLARIS dealer to purchase a replacement. Replacement safety labels are provided by POLARIS at no charge. The part number is printed on the label.
Image
The safety labels are located on the front ROPS, above the driver’s head.

Proper Use Warning

WARNING
Require Proper Use of Your Vehicle
Do your part to prevent injuries:
  • Do not allow careless or reckless driving.
  • Make sure operators are 16 or older with a valid driver’s license.
  • Do not let people drive after using alcohol or drugs.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
  • Do not exceed seating capacity: 3 occupants.
Driving on public roads may be hazardous and could be a violation of the law.

Seat Belt / Drive Responsibly Warning

WARNING
Improper vehicle use can result in SEVERE INJURY or DEATH
Be Prepared
  • Fasten seat belts.
  • Wear an approved helmet and protective gear.
  • ALWAYS use vehicle cab doors if equipped.
  • Each rider must be able to sit with back against seat, feet flat on the floor, and hands on steering wheel or handholds. Stay completely inside the vehicle.
Drive Responsibly
  • Avoid loss of control and rollovers.
  • Avoid abrupt maneuvers, sideways sliding, skidding, or fishtailing, and never do donuts.
  • Slow down before entering a turn.
  • Avoid hard acceleration when turning, even from a stop.
  • Plan for hills, rough terrain, ruts, and other changes in traction and terrain. Avoid paved surfaces.
  • Avoid side hilling (riding across slopes).
Be Sure Riders Pay Attention and Plan Ahead
If you think or feel the vehicle may tip or roll, reduce your risk to injury:
  • Keep a firm grip on the steering wheel or handholds and brace yourself.
  • Do not put any part of your body outside of the vehicle for any reason.
Rollovers have caused severe injuries and death, even on flat, open areas.

Clutch Cover Warning

WARNING

The Clutch Cover Warning is located on the clutch cover.

  • Moving parts hazard under belt-clutch guard. To prevent serious injury, do not operate vehicle with guard removed.
  • Do not modify engine or clutch. Doing so can cause part failure, possible imbalance, and excessive engine RPM which can result in serious injury or death.

Image

LOAD/PASSENGER/TIRE PRESSURE WARNING

WARNING
  • Never carry passengers in cargo box.
  • Passengers can be thrown off. This can cause serious injury or death.
  • If total payload is greater than 500 lbs, the vehicle must be operated in LOW range.
WARNING
IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTING IN SERIOUS INJURY OR DEATH.
  • Reduce speed and allow greater distance for braking when carrying cargo.
  • Overloading or carrying tall, off-center, or unsecured loads will increase your risk of losing control. Loads should be centered and carried as low as possible in box.
  • For stability on rough or hilly terrain, reduce speed and cargo.
Ranger 1000 CA 1000
MAXIMUM CARGO BOX LOAD

1000 lbs.

(454 kg)

600 lbs.

(272 kg)
TIRE PRESSURE IN PSI (KPa)

FRONT 10 (69)

REAR 14 (97)

FRONT 10 (69)

REAR 14 (97)
MAXIMUM WEIGHT CAPACITY
INCLUDES WEIGHT OF OPERATOR, PASSENGER,CARGO, AND ACCESSORIES.

1500 lbs.

(682 kg)

1100 lbs.

(499 kg)
Read Operation & Maintenance Manual for more detailed loading information.

Air Box Caution (7182652)

CAUTION
Use a Polaris approved air filter. The use of a non-Polaris approved air filter may cause engine damage. Before installing filter, ensure there is no dirt or debris in the clean side of the intake tube. The air filter must be properly seated before the lid is reinstalled. Please reference your owner’s manual for additional information regarding air filter service.

Fuel Transport Warning

The Fuel Transport Warning is located in the cargo box.
WARNING
NEVER carry fuel or other flammable liquids on this vehicle. Failure to follow this instruction could lead to serious burn injuries or death.

Image

Belt Warning

WARNING
Improper service or maintenance of this PVT system can result in vehicle damage, SEVERE INJURY or DEATH.
Always look for and remove debris inside and around clutch and vent system when replacing belt.
Read owner’s manual or see authorized Polaris dealer.

© Copyright Polaris Industries Inc. All rights reserved.