Safety Labels and Locations

Content Source: 2020 RANGER 570 Full-Size Owner’s Manual (9929907 R02) > Safety Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Safety Labels and Locations

Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle.

If an informational or graphic label becomes illegible or comes off, contact your POLARIS dealer to purchase a replacement. Replacement safety labels are provided by POLARIS at no charge. The part number is printed on the label.

Proper Use Warning
Max Payload Warning

Shift Caution
Seat Belt / Driver Warning

Maximum Payload Warning

WARNING

RANGER	Never Exceed	If Total Payload Exceeds
4x4	10 mph (16 km/h)	530 lbs. (240 kg)
CA 4x4	20 mph (30 km/h)	530 lbs. (240 kg)
4x4 Crew	35 mph (56 kph)	835 lbs. (379 kg)
CA 4x4 Crew	35 mph (56 kph)	835 lbs. (379 kg)

Shift Caution

CAUTION

To avoid transmission damage, shift only when vehicle is stationary and at idle. APPLY BRAKE TO START. When this vehicle is not in operation, or unattended, place shift in the park position.

Seat Belt / Drive Responsibly Warning

WARNING

Improper vehicle use can result in SEVERE INJURY or DEATH

Be Prepared

Fasten seat belts.
Wear an approved helmet and protective gear.
ALWAYS use vehicle cab doors if equipped.
Each rider must be able to sit with back against seat, feet flat on the floor, and hands on steering wheel or handholds. Stay completely inside the vehicle.

Drive Responsibly

Avoid loss of control and rollovers.
Avoid abrupt maneuvers, sideways sliding, skidding, or fishtailing, and never do donuts.
Slow down before entering a turn.
Avoid hard acceleration when turning, even from a stop.
Plan for hills, rough terrain, ruts, and other changes in traction and terrain. Avoid paved surfaces.
Avoid side hilling (riding across slopes).

Be Sure Riders Pay Attention and Plan Ahead

If you think or feel the vehicle may tip or roll, reduce your risk to injury:

Keep a firm grip on the steering wheel or handholds and brace yourself.
Do not put any part of your body outside of the vehicle for any reason.

Rollovers have caused severe injuries and death, even on flat, open areas.

Proper Use Warning

WARNING

Require Proper Use of Your Vehicle

Do your part to prevent injuries:

Do not allow careless or reckless driving.
Make sure operators are 16 or older with a valid driver’s license.
Do not let people drive after using alcohol or drugs.
Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
Do not exceed seating capacity: 3 occupants.

Driving on public roads may be hazardous and could be a violation of the law.

Proper Use Warning (Crew)

WARNING

Require Proper Use of Your Vehicle

Do your part to prevent injuries:

Do not allow careless or reckless driving.
Make sure operators are 16 or older with a valid driver’s license.
Do not let people drive after using alcohol or drugs.
Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
Do not exceed seating capacity: 6 occupants.

Driving on public roads may be hazardous and could be a violation of the law.

Passenger/Tire Pressure Warning

The Passenger/Tire Pressure warning label

is located in the cargo box.

WARNING

Passengers can be thrown off. This can cause serious injury or death.
Never carry passengers in cargo box.

WARNING

IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTING IN SERIOUS INJURY OR DEATH.

Reduce speed and allow greater distance for braking when carrying cargo.
Overloading or carrying tall, off-center, or unsecured loads will increase your risk of losing control. Loads should be centered and carried as low as possible in box.
For stability on rough or hilly terrain, reduce speed and cargo.
If total payload is greater than 500 lbs. (227 kg), the vehicle must be operated in LOW range.

RANGER®	4x4	CA 4x4	CREW	CA 4x4 CREW
MAXIMUM CARGO BOX LOAD	800 lbs (362 kg)	600 lbs. (272 kg)	800 lbs (362 kg)	600 lbs (272 kg)
TIRE PRESSURE IN PSI (KPa)	FRONT 10 (69) REAR 10 (69)	FRONT 10 (69) REAR 10 (69)	FRONT 10 (69) REAR 18 (124)	FRONT 10 (69) REAR 18 (124)
MAXIMUM WEIGHT CAPACITY INCLUDES WEIGHT OF OPERATOR, PASSENGER, CARGO AND ACCESSORIES	1500 lbs. (682 kg)	1300 lbs. (589 kg)	1500 lbs. (682 kg	1300 lbs. (589 kg)
Read Operation & Maintenance Manual for more detailed loading information.

Clutch Cover Warning

WARNING

The Clutch Cover Warning is located on the clutch cover.

Moving parts hazard under belt-clutch guard. To prevent serious injury, do not operate vehicle with guard removed.
Do not modify engine or clutch. Doing so can cause part failure, possible imbalance, and excessive engine RPM which can result in serious injury or death.

Fuel Transport Warning

The Fuel Transport Warning is located in the cargo box.

WARNING

NEVER carry fuel or other flammable liquids on this vehicle. Failure to follow this instruction could lead to serious burn injuries or death.

Operator Safety

WARNING

Serious injury or death can result if you do not follow these instructions and procedures, which are outlined in further detail within your owner's manual.

Read this entire manual and all labels carefully. Follow the operating procedures described.
Never allow anyone under the age of 16 to operate this vehicle and never allow anyone without a valid driver's license to operate this vehicle.
Do not carry a passenger until you have at least two hours of driving experience with this vehicle.
All riders must be able to sit with backs against the seat, both feet flat on the floor and both hands on the steering wheel (if driving) or on a passenger hand hold.
The driver and all passengers must wear helmets, eye protection, gloves, long-sleeve shirts, long pants, over-the-ankle boots and their seat belts at all times.
Always use the cab nets (or doors) while riding in this vehicle.
Always keep hands and feet inside the vehicle at all times.
Always keep both hands on the steering wheel and both feet on the floorboards of the vehicle during operation.
Never permit a guest to operate this vehicle unless the guest has read this manual and all product labels.
To reduce rollover risk, be especially careful when encountering obstacles and slopes and when braking on hills or during turns.
This vehicle is for off road use only. Never operate on public roads (unless marked for off-road use). Always avoid paved surfaces.
Never consume alcohol or drugs before or while operating this vehicle.
Never operate at excessive speeds. Always travel at a speed proper for the terrain, visibility and operating conditions, and your experience.
Never attempt jumps or other stunts.
Always inspect the vehicle before each use to make sure it's in safe operating condition.
Always follow the inspection procedures described in this manual.
Always travel slowly and use extra caution when operating on unfamiliar terrain. Be alert to changing terrain.
Never operate on excessively rough, slippery or loose terrain.
Always follow proper procedures for turning. Practice turning at slow speeds before attempting to turn at faster speeds. Never turn at excessive speeds.
Always have this vehicle checked by an authorized POLARIS dealer if it has been involved in an accident.
Never operate this vehicle on hills too steep for the vehicle or for your abilities. Practice on smaller hills before attempting larger hills.
Always follow proper procedures for climbing hills as described in this manual. Check the terrain carefully before attempting to climb a hill. Never climb hills with excessively slippery or loose surfaces. Never apply throttle suddenly. Never make sudden gear changes. Never go over the top of a hill at high speed.
Always follow the proper procedures outlined in this manual for traveling downhill and for braking on hills. Check the terrain carefully before descending a hill. Never travel downhill at high speed. Avoid going downhill at an angle, which would cause the vehicle to lean sharply to one side. Travel straight down the hill where possible.
Always check for obstacles before operating in a new area. Never attempt to operate over large obstacles such as large rocks or fallen trees. Always follow the proper procedures outlined in this manual when operating over obstacles.
Always be careful of skidding or sliding. On slippery surfaces such as ice, travel slowly and exercise caution to reduce the chance of skidding or sliding out of control.
Never operate your vehicle in fast-flowing water or in water deeper than that specified in this manual. Wet brakes may have reduced stopping ability. Test your brakes after leaving water. If necessary, apply them lightly several times to let friction dry out the pads.
Always be sure there are no obstacles or people behind your vehicle when operating in reverse. When it's safe to proceed in reverse, move slowly. Avoid turning at sharp angles in reverse.
Always use the proper size and type of tires specified in this manual. Always maintain proper tire pressure as specified on safety labels. Failure to adhere to either may impact vehicle stability, driveline durability, or general vehicle handling.
Never modify this vehicle through improper installation or use of non-POLARIS approved accessories.
Always re-install plastics and heat shields after vehicle is serviced.
Never exceed the stated load capacity for this vehicle. Cargo should be properly distributed and securely attached. Reduce speed and follow the instructions in this manual for hauling cargo or pulling a trailer. Allow a greater distance for braking.
Always place the transmission in PARK before getting out of the vehicle.
Always engage the park brake (if equipped) when leaving the vehicle unattended.
Always stop the engine before refueling. Make sure the refueling area is well ventilated and free of any source of flame or sparks.
Always remove the ignition key when the vehicle is not in use to prevent unauthorized use by someone under the age of 16 or without a driver’s license and proper training, or accidental starting.