Content Source: 2020 GENERAL 4 1000 Owner’s Manual (9929902 R3) > Safety Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Safety Labels and Locations

Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle.
If any label becomes illegible or comes off, contact your POLARIS dealer to purchase a replacement. Replacement safety labels are provided by POLARIS at no charge. The part number is printed on the label.

Proper Use Warning (7182649)

The Proper Use Warning is located on the center console.
Require Proper Use of Your Vehicle
Do your part to prevent injuries:

  • Do not allow careless or reckless driving.
  • Make sure operators are 16 or older with a valid driver’s license.
  • Do not let people drive or ride after using alcohol or drugs.
  • Do not allow operation on public roads (unless designated for off-highway vehicle access) - collisions with cars and trucks can occur.
  • Do not exceed seating capacity: 2 occupants

Image

Payload Warning / Shift Caution (7185784)

The Payload/Shift Caution safety label is located on the center console.
WARNING
POLARIS Never Exceed If Total Payload Exceeds
GENERAL 43 MPH (69 kph) 430 lbs. (195 kg)
GENERAL 4 50 MPH (80 kph) 645 lbs. (292 kg)
CAUTION
To avoid transmission damage, shift only when vehicle is stationary and at idle. When vehicle is stopped, place shift in parked position.

Seat Belt/Drive Responsibly Warning

WARNING
Improper vehicle use can result in SEVERE INJURY or DEATH
BE PREPARED
  • Fasten seat belts.
  • Wear an approved helmet and protective gear.
  • ALWAYS use cab nets and/or doors.
  • Each rider must be able to sit with back against seat, feet flat on the floor, and hands on steering wheel or hand holds. Stay completely inside the vehicle.
Drive Responsibly
Avoid loss of control and rollovers:
  • Avoid abrupt maneuvers, sideways sliding, skidding or fishtailing, and never do donuts.
  • Slow down before entering a turn.
  • Avoid hard acceleration when turning, even from a stop.
  • Plan for hills, rough terrain, ruts and other changes in traction and terrain. Avoid paved surfaces.
  • Avoid sidehilling (riding across slopes).
Be Sure Riders Pay Attention and Plan Ahead
If you think or feel the vehicle may tip or roll, reduce your risk of injury:
  • Keep a firm grip on the steering wheel or hand holds and brace yourself.
  • Do not put any part of your body outside of the vehicle for any reason.
LOCATE AND READ OWNER’S MANUAL. FOLLOW ALL INSTRUCTIONS AND WARNINGS. ALWAYS REVIEW SAFETY VIDEO AND TAKE ROHVA TRAINING (rohva.org).

Fuel Transport Warning (7185278)

The Fuel Transport Warning is located in the cargo box.
WARNING
NEVER carry fuel or other flammable liquids on this vehicle. Failure to follow this instruction could lead to serious burn injuries or death.

Clutch Cover Warning (7177469)

  • The clutch cover warning is located on the clutch cover.
  • WARNING
  • Improper service or maintenance of this PVT system can result in vehicle damage, SEVERE INJURY or DEATH.
  • Always look for and remove debris inside and around clutch and vent system when replacing belt.
  • Read owner’s manual or see authorized POLARIS dealer.

Image

Load / Passenger / Tire Pressure Warning (7190994)

  • The Load/Passenger/Tire Pressure warning decal is located on the front panel of the rear cargo box .
  • WARNING
  • Never carry passengers in cargo box.
  • Passengers can be thrown off. This can cause serious injury or death.
  • If total payload is greater than 500 lbs., the vehicle must be operated in LOW range.

Image
IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTING IN SERIOUS INJURY OR DEATH.
  • Reduce speed and allow greater distance for braking when carrying cargo.
  • Overloading or carrying tall, off-center, or unsecured loads will increase your risk of losing control. Loads should be centered and carried as low as possible in box.
  • For stability on rough or hilly terrain, reduce speed and cargo.

RANGER

GENERAL BASE
(12–inch Wheels)

GENERAL
(14–inch Wheels)

GENERAL 4

MAXIMUM CARGO BOX LOAD

600 lbs.


(272 Kg)

600 lbs.


(272 Kg)

600 lbs.


(272 Kg)

TIRE PRESSURE IN PSI (KPa)

FRONT 10 (69)


REAR 18 (125)

FRONT 12 (87)


REAR 14 (96)

FRONT 18 (124)


REAR 20 (137)

MAXIMUM WEIGHT CAPACITY


INCLUDES WEIGHT OF OPERATOR, PASSENGERS, CARGO, AND ACCESSORIES

1030 lbs.


(467 Kg)

1030 lbs.


(467 Kg)

1280 lbs.


(580 Kg)

Read Operation and Maintenance Manual for more detailed loading information.

International Labels

General Alerts (7185984)

  • Always read the owner’s manual.
  • Never allow anyone under 16 years of age to operate this vehicle.
  • Always use the cab nets or doors.
  • Avoid operating in a manner that could result in a rollover.
  • This vehicle is not approved for on-road operation.
  • Never use alcohol or drugs before or while driving or riding.
  • Always wear seat belts.
  • Wear approved helmet, goggles, and protective clothing.
  • Avoid exhibition driving.

General Alerts Location
(between seats, above armrest)
Image

Clutch Cover Alert (P/N 7181427)

Keep body parts away from belt.
Label Location: on the clutch cover.

Image

Intake Alert (7185975)

Use a Polaris approved air filter. The use of a non-Polaris approved air filter may cause engine damage. Before installing filter ensure there is no dirt or debris in the clean side of the intake tube. The air filter must be properly seated and the hinges fully inserted when the lid is reinstalled. Please reference your owner’s manual for additional information regarding the air filter service.
Label Location: on the air box.

Image

Shift Alert (7183987)

  • To avoid transmission damage, shift only when vehicle is stationary and at idle.
  • APPLY BRAKE TO START. When this vehicle is not in operation, or unattended, place shift in the park position.
Shift Alert Location

Image

Tire Pressure / Passenger Alert (7190997)

Never carry passengers in cargo box. Passengers can be thrown off. This can cause serious injury or death. Read owner’s manual. Never carry or transport fuel on this vehicle. The Tire Pressure / Passenger Alert decal is located on the front panel of the rear cargo box .

Image
Image
Vehicle Maximum Cargo Box Load Maximum Capacity Tire Pressure in kpa/bar
GENERAL 272 kg Occupants: 2 (Driver + 1 Passengers)
Weight: 467 kg
Front: 69 kPa/0,69 bar
Rear: 125 kPa/1,25 bar
GENERAL 4 272 kg Occupants: 4 (Driver + 3 Passengers)
Weight: 580 kg
Front: 124 kPa/1,24 bar
Rear: 137 kPa/1,37 bar

© Copyright Polaris Industries Inc. All rights reserved.