Content Source: 2020 Indy 120 Owner’s Manual (9929777 R01) > Maintenance Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Track Inspection

WARNING
Inspecting the track while the engine is running can result in serious personal injury if the track should being to move. Never inspect the track with the engine running. Never hold the snowmobile up or stand behind it while rotating the track. A loose track or flying debris could cause serious personal injury or death.

Check track condition at the intervals outlined in the periodic maintenance chart beginning on Periodic Maintenance Chart.

  • Common Breakage Areas
  • Lug
  • Track Window

Image

  1. Support the rear of the snowmobile slightly off the ground with an appropriate snowmobile support.
  2. Rotate the track by hand to check for wear or damage.
  3. Carefully examine the track along the entire length of each track rod, bending the track and inspecting for breakage.
    TIP
    The three most common places where breakage occurs are shown in the illustration .
  4. Check the track clips and tighten any loose clips. If any rod damage is found, install a new track.
    TIP
    This snowmobile track has molded-in track clips. It is common for a thin layer of rubber to detach from the clip area and peel off during initial use.

© Copyright Polaris Industries Inc. All rights reserved.