Content Source: 2020 600 Indy Owner's Manual (9929776 R02) > Maintenance Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Periodic Maintenance Interval Table

The following chart is a guide based on average riding conditions. You may need to increase frequency based on riding conditions. When inspection reveals the need for replacement parts, always use genuine POLARIS parts, available from your POLARIS dealer.

I - Inspect (clean, adjust, tighten, lubricate, replace if necessary)
C - Clean, R - Replace, L - Lubricate

Item

Frequency

150 mi.
(240 km)

500 mi.
(800 km)

1000 mi. (1600 km)

2000 mi. (3200 km)

Pre- Season

Clutch

Clutch Alignment Offset (without belt)

(See Clutch Alignment Offset.

  I I I  

Drive Belt Condition

(See Drive Belt Condition)

 

I

I

I

I

Clutches

(See Clutch System)

 

C

C

C

  

Belt Tension

  

I

I

I

I

Clutch Sheaves

(See Clutch System)

 

I

I

I

I

ENGINE/COOLING

Engine Mounts

  

I

I

I

I

Recoil Rope

  

I

I

I

I
Cylinder Head Bolts   I I I  
Cylinder Base Nuts   I I I  
Ignition Timing BTDC   I I I  
VES System   C C C I
Coolant Level (See Coolant Level)   I I I I
Coolant Change R - Every 5 Years
Coolant Hose   I I I I
Coolant Circulation   I I I  
Coolant Leaks   I I I I

Spark Plugs

(See Spark Plug Recommendations)

 

I

I

R

I

Exhaust Pipe

(See Exhaust System)

     

I

I

Exhaust Retaining Springs

(See Exhaust System)

 

I

I

I

I

Brakes

Hose Routing

  

I

I

I

I

Hose Condition

  

I

I

I

I

Fluid Leaks

  

I

I

I

I

Brake Pads

(See Hydraulic Brake Inspection)

 

I

I

I

I

Brake Disc

  

I

I

I

I

Parking Brakes

(See Parking Brake Lever Lock)

 

I

I

I

I

Brake System

(See Brakes., Hydraulic Brake Inspection)

       

I

Brake Fluid

(See Brake Fluid)

     

I

  

FUEL MANAGEMENT
Idle RPM   I I I  

Throttle Lever

(See Throttle Lever)

I

I

I

I

I
Oil Pump Lever (synchronize)   I I I  
Throttle Position Sensor   I I I  

Fuel / Vent Hoses

(See Fuel Filter / Fuel Lines)

I

I

I

I

I
Fuel Filter

(See Fuel Filter / Fuel Lines)

R – Every 2000 mi. (3200 km) or Every 2 years
Oil Filter (See Oil Filter)       R  

Oil Lines

(See Fuel Filter / Fuel Lines)

   

I

I

I

Air Box

I

I

I

I

I

ELECTRICAL

Auxiliary Shut-Off

(See Engine Stop Switch)

I

I

I

I

I

Throttle Safety Switch

(See Throttle Safety Switch)

I

I

I

I

I

Ignition Switch

I

I

I

I

I

Taillight

(See Lighting)

I

I

I

I

I

Brakelight

(See Lighting)

I

I

I

I

I

Headlight

(See Lighting)

I

I

I

I

I

CHASSIS

Ski Toe Alignment

  

I

I

I

  

Suspension Mounting Bolts

I

I

I

I

I

Bolt Torques

 See your dealer every 1000 mi. (1600 km) for inspection

Steering Fasteners

I

I

I

I

C

Rear Suspension Fasteners

I

I

I

I

I
Suspension Shock Oil (SP Models)       R  
Cooling Fins and Shroud   I I I I

Skags (Wear Bars)

(See Ski Skags)

I

I

I

I

I

Ski Saddle/Spindle Bolts

I

I

I

I

I

Drive Chain Tension

(See Drive Chain Tension)

I

I

I

I

I

Hood and Side Panel Fasteners

(See Hood and Side Panel Fasteners)

I

I

I

I

I

Rear Wheel Idler Bolts

(See Track Tension)

I

I

I

I

I

Idler Bolt Jam Nut

(See Track Tension)

I

I

I

I

I
Camber Alignment   I I I  

Handlebar Centering

        

I

Tether Switch and Strap

(See Tether Switch (if equipped))

I

I

I

I

I

Track Tension

(See Track Tension)

I

I

I

I

I

Track Alignment

(See Track Alignment)

I

I

I

I

I

Front Limiter Strap

I

I

I

I

I

Rail Slide Condition

(See Rail Slide Wear)

       

I

Chaincase Oil

(See Chaincase Oil (if equipped))

I

R

I

R

I

© Copyright Polaris Industries Inc. All rights reserved.