Content Source: 2019 RZR 570 Owner’s Manual (9929131 Rev 02) > Maintenance Chapter

IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle.Always follow the warnings and instructions in Owner's Manual.

Click the CONTENTS link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com

Periodic Maintenance Chart

Any qualified repair shop or person may maintain, replace or repair the emission control devices or systems on your vehicle. An authorized POLARIS dealer can perform any service that may be necessary for your vehicle. POLARIS also recommends POLARIS parts for emissions-related service, however equivalent parts can be used.
It is a potential violation of the Clean Air Act if a part supplied by an aftermarket parts manufacturer reduces the effectiveness of the vehicle’s emission controls. Tampering with emission controls is prohibited by federal law.
Owners are responsible for performing the scheduled maintenance identified in this owner’s manual.
Careful periodic maintenance will help keep your vehicle in the safest, most reliable condition. Inspection, adjustment and lubrication of important components are explained in the periodic maintenance chart.
Inspect, clean, lubricate, adjust and replace parts as necessary. When inspection reveals the need for replacement parts, genuine POLARIS parts are available from your POLARIS dealer. Equivalent parts may be used for emissions-related service.
Service and adjustments are important for proper vehicle operation. If you're not familiar with safe service and adjustment procedures, a qualified dealer can perform these operations.
Vehicles subjected to heavy or severe use patterns must be inspected and serviced more frequently.

Severe Use Definition

  • Frequent immersion in mud, water or sand
  • Frequent or prolonged operation in dusty environments
  • Racing or race-style high RPM use
  • Prolonged low speed, heavy load operation
  • Extended idle
  • Short trip cold weather operation
Pay special attention to the oil level. A rise in oil level during cold weather can indicate contaminants collecting in the oil sump or crankcase. Change oil immediately if the oil level begins to rise. Monitor the oil level, and if it continues to rise, discontinue use and determine the cause. Your POLARIS dealer can assist.

Maintenance Chart Key

Symbol Description
XU

Perform these procedures more often for vehicles subjected to severe use.
D

Have an authorized POLARIS dealer or other qualified person perform these services.
WARNING
Improperly performing the procedures marked with a D could result in component failure and lead to serious injury or death. Have an authorized POLARIS dealer or other qualified person perform these services.

Maintenance Chart Table

Perform all services at whichever maintenance interval is reached first. Record maintenance and service in the Maintenance Log on Maintenance Log.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours CLNDR Miles (Km)
 

Steering

  

Pre-Ride

  

Inspect and make adjustments as needed. See the Pre-Ride Inspection section for details.
 

Front suspension
 

Rear suspension
 

Tires
 

Brake fluid level
 

Brake pedal travel
 

Brake system
 

Wheels/fasteners
 

Frame fasteners
 

Engine oil level
 

Intake pre-filters
 

Coolant

-

Daily

-

Check level

XU

Power steering unit (if equipped)

-

Daily

-

Inspect daily; clean often
 

Headlamp/tail lamp

-

Daily

-

Check operation; apply dielectric grease if replacing

XU

Air filter, main element

-

Weekly

-

Inspect; replace as needed

XU
D

Brake pad wear

10 H

Monthly

100 (160)

Inspect periodically

XU

Engine breather

25 H

Monthly

150 (250)

Inspect; replace if necessary
 

Fuel System

25 H

Monthly

150 (250)

Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
 

Battery

25 H

Monthly

250 (400)

Check terminals; clean; test

XU

Engine oil change

25 H

Monthly

-

Break-in oil and filter change

XU

Demand drive fluid

25 H

Monthly

-

Break-in oil level check

XU

Transmission oil (main gearcase)

25 H

Monthly

-

Break-in oil level check
 

Throttle body air intake ducts/flange

50 H

6 M

300 (500)

Inspect duct for proper sealing/air leaks

XU

General lubrication

50 H

3 M

500 (800)

Lubricate all fittings, pivots, cables, etc.

XU

Oil lines, fasteners (if equipped)

50 H

6 M

500 (800)

Inspect for leaks and loose fittings
 

Shift Linkage

50 H

6 M

500 (800)

Inspect, lubricate, adjust

D

Steering

50 H

6 M

500 (800)

Lubricate

XU

Front Suspension

50 H

6 M

500 (800)

Lubricate

XU

Rear Suspension

50 H

6 M

500 (800)

Lubricate
 

Cooling system

50 H

6 M

500 (800)

Inspect coolant strength seasonally; pressure test system yearly

XU

Engine oil change

100 H

6 M

1000 (1600)

Change the oil and filter

D

Fuel system

100 H

12 M

600 (1000)

Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump; replace lines every two years

XU

Spark plug

100 H

12 M

600 (1000)

Inspect; replace as needed

XU

Demand drive fluid

100 H

12 M

-

Change fluid

XU

Transmission oil (main gearcase)

100 H

12 M

-

Change fluid

XU

Radiator

100 H

12 M

1000 (1600)

Inspect; clean external surfaces

XU

Cooling Hoses

100 H

12 M

1000 (1600)

Inspect for leaks

XU

Engine mounts

100 H

12 M

1000 (1600)

Inspect
 

Exhaust muffler/pipe

100 H

12 M

1000 (1600)

Inspect

XU

Wiring

100 H

12 M

1000 (1600)

Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc.

D

Clutches (drive and driven)

100 H

12 M

1000 (1600)

Inspect; clean; replace worn parts
 

Drive belt

100 H

12 M

1000 (1600)

Inspect; replace as needed

D

Front wheel bearings

100 H

12 M

1000 (1600)

Inspect; replace as needed

D

Brake fluid

200 H

24 M

2000 (3200)

Change every two years
 

Suspension bushings

250 H

24 M

2000 (3200)

Inspect; replace if necessary
 

Spark arrester

200 H

24 M

2000 (3200)

Clean daily when driving in mud and water; replace a cracked or damaged arrester before operating (see the Spark Arrester section in this chapter)

XU

Coolant

-

60 M

-

Replace coolant

XU

Valve clearance

500 H

-

5000 (8000)

Inspect; adjust as needed

D

Toe adjustment

-

Inspect periodically; adjust when parts are replaced
 

Headlight aim

-

Adjust as needed
XU – Perform these procedures more often for vehicles subjected to severe use.
D – Have an authorized POLARIS dealer or other qualified person perform these services.

© Copyright Polaris Inc. All rights reserved.